Considerations for deriving a safe intake of propylene glycol.

The use of propylene glycol (PG) in food and other applications is widespread, and some estimates of dietary exposure to PG approach or exceed the Acceptable Daily Intake (ADI) of 25 mg/kg bw-day. The current ADI for PG applies a cumulative uncertainty factor of 100, which includes factors of 10 for both interspecies and intraspecies differences. Available toxicology studies and human data, however, indicate a plausible mode of action (MoA) that would support a chemical-specific adjustment factor (CSAF) of 1 for interspecies toxicodynamic differences, reducing the total uncertainty factor from 100 to 40. The MoA involves an increase in serum PG concentrations after metabolic saturation, leading to serum hyperosmolarity, which can ultimately cause hemolytic changes and red blood cell damage. Therefore, the species similarities in toxicodynamic response for this critical effect could support increasing the ADI from 25 to 62.5 mg/kg bw-day, applicable to both children and adults.

In vitro toxicological evaluation of aerosols generated by a 4th generation vaping device using nicotine salts in an air-liquid interface system.

BACKGROUND: Electronic cigarettes (EC) have gained popularity, especially among young people, with the introduction of fourth-generation devices based on e-liquids containing nicotine salts that promise a smoother vaping experience than freebase nicotine. However, the toxicological effects of nicotine salts are still largely unknown, and the chemical diversity of e-liquids limits the comparison between different studies to determine the contribution of each compound to the cytotoxicity of EC aerosols. Therefore, the aim of this study was to evaluate the toxicological profile of controlled composition e-liquid aerosols to accurately determine the effects of each ingredient based on exposure at the air-liquid interface. METHODS: Human lung epithelial cells (A549) were exposed to undiluted aerosols of controlled composition e-liquids containing various ratios of propylene glycol (PG)/vegetable glycerin (VG) solvents, freebase nicotine, organic acids, nicotine salts, and flavoured commercial e-liquids. Exposure of 20 puffs was performed at the air-liquid interface following a standard vaping regimen. Toxicological outcomes, including cytotoxicity, inflammation, and oxidative stress, were assessed 24 h after exposure. RESULTS: PG/VG aerosols elicited a strong cytotoxic response characterised by a 50% decrease in cell viability and a 200% increase in lactate dehydrogenase (LDH) production, but had no effects on inflammation and oxidative stress. These effects occurred only at a ratio of 70/30 PG/VG, suggesting that PG is the major contributor to aerosol cytotoxicity. Both freebase nicotine and organic acids had no greater effect on cell viability and LDH release than at a 70/30 PG/VG ratio, but significantly increased inflammation and oxidative stress. Interestingly, the protonated form of nicotine in salt showed a stronger proinflammatory effect than the freebase nicotine form, while benzoic acid-based nicotine salts also induced significant oxidative stress. Flavoured commercial e-liquids was found to be cytotoxic at a threshold dose of ≈ 330 µg/cm². CONCLUSION: Our results showed that aerosols of e-liquids consisting only of PG/VG solvents can cause severe cytotoxicity depending on the concentration of PG, while nicotine salts elicit a stronger pro-inflammatory response than freebase nicotine. Overall, aerosols from fourth-generation devices can cause different toxicological effects, the nature of which depends on the chemical composition of the e-liquid.

Conventional and multi-omics assessments of subacute inhalation toxicity due to propylene glycol and vegetable glycerin aerosol produced by electronic cigarettes.

Propylene glycol (PG) and vegetable glycerin (VG) are the most common solvents used in electronic cigarette liquids. No long-term inhalation toxicity assessments have been performed combining conventional and multi-omics approaches on the potential respiratory effects of the solvents in vivo. In this study, the systemic toxicity of aerosol generated from a ceramic heating coil-based e-cigarette was evaluated. First, the aerosol properties were characterized, including carbonyl emissions, the particle size distribution, and aerosol temperatures. To determine toxicological effects, rats were exposed, through their nose only, to filtered air or a propylene glycol (PG)/ glycerin (VG) (50:50, %W/W) aerosol mixture at the target concentration of 3 mg/L for six hours daily over a continuous 28-day period. Compared with the air group, female rats in the PG/VG group exhibited significantly lower body weights during both the exposure period and recovery period, and this was linked to a reduced food intake. Male rats in the PG/VG group also experienced a significant decline in body weight during the exposure period. Importantly, rats exposed to the PG/VG aerosol showed only minimal biological effects compared to those with only air exposure, with no signs of toxicity. Moreover, the transcriptomic, proteomic, and metabolomic analyses of the rat lung tissues following aerosol exposure revealed a series of candidate pathways linking aerosol inhalation to altered lung functions, especially the inflammatory response and disease. Dysregulated pathways of arachidonic acids, the neuroactive ligand-receptor interaction, and the hematopoietic cell lineage were revealed through integrated multi-omics analysis. Therefore, our integrated multi-omics approach offers novel systemic insights and early evidence of environmental-related health hazards associated with an e-cigarette aerosol using two carrier solvents in a rat model.

Effects of electronic cigarette E-liquid and device wattage on vascular function.

Electronic cigarettes (e-cigs) are customizable tobacco products that allow users to select e-liquid composition, flavors, and (in some devices) adjust wattage or heat used to generate e-cig aerosol. This study compared vascular outcomes in a conducting vessel (thoracic aorta) and a resistance artery (middle cerebral artery, MCA) in C57Bl/6 mice exposed to e-cig aerosol generated from either pure vegetable glycerin (VG) or pure propylene glycol (PG) over 60-min (Study 1), and separately the effect of using 5- vs. 30-watt settings with an exposure of 100-min (Study 2). In Study 1, aortic endothelial-dependent-dilation (EDD) was only impaired with PG- exposure (p < 0.05) compared with air. In the MCA, EDD response was impaired by ∼50% in both VG and PG groups compared with air (p < 0.05). In Study 2, the aortic EDD responses were not different for either 5- or 30-watt exposed groups compared with air controls; however, in the MCA, both 5- and 30-watt groups were impaired by 32% and 55%, respectively, compared with air controls (p < 0.05). These pre-clinical data provide evidence that chronic exposure to aerosol produced by either VG or PG, and regardless of the wattage used, leads to vascular dysfunction at multiple levels within the arterial system. For all exposures, we observed greater impairment of arterial reactivity in a resistance artery (i.e. MCA) compared with the aorta. These data could suggest the smaller arteries may be more sensitive or first to be affected, or that different mechanism(s) for impairment may be involved depending on arterial hierarchy.

Comparative study of lung toxicity of E-cigarette ingredients to investigate E-cigarette or vaping product associated lung injury.

No comparative study has yet been performed on the respiratory effects of individual E-cigarette ingredients. Here, lung toxicity of individual ingredients of E-cigarette products containing nicotine or tetrahydrocannabinol was investigated. Mice were intratracheally administered propylene glycol (PG), vegetable glycerin (VG), vitamin E acetate (VEA), or nicotine individually for two weeks. Cytological and histological changes were noticed in PG- and VEA-treated mice that exhibited pathophysiological changes which were associated with symptoms seen in patients with symptoms of E-cigarette or Vaping Use-Associated Lung Injuries (EVALI) or E-cigarette users. Compared to potential human exposure situations, while the VEA exposure condition was similar to the dose equivalent of VEA content in E-cigarettes, the PG condition was about 47-137 times higher than the dose equivalent of the daily PG intake of E-cigarette users. These results reveal that VEA exposure is much more likely to cause problems related to EVALI in humans than PG. Transcriptomic analysis revealed that PG exposure was associated with fibrotic lung injury via the AKT signaling pathway and M2 macrophage polarization, and VEA exposure was associated with asthmatic airway inflammation via the mitogen-activated protein kinase signaling pathway. This study provides novel insights into the pathophysiological effects of individual ingredients of E-cigarettes.

Hematological variations in healthy participants exposed 2 h to propylene glycol ethers under controlled conditions.

Glycol ethers are solvents used in a plethora of occupational and household products exposing the users to potential toxic effects. Several glycol ethers derived from ethylene glycol induce hematological toxicity, such as anemia in workers. The exposure effects on blood cells of glycol ethers derived from propylene glycol are unknown in humans. The aim of our study was to evaluate blood parameters indicative of red blood cell (RBC) hemolysis and oxidative stress in participants exposed to propylene glycol (propylene glycol monobutyl ether (PGBE) and propylene glycol monomethyl ether (PGME)), two extensively used propylene glycol derivatives worldwide. Seventeen participants were exposed 2 h in a control inhalation exposure chamber to low PGME (35 ppm) and PGBE (15 ppm) air concentrations. Blood was regularly collected before, during (15, 30, 60, and 120 min), and 60 min after exposure for RBC and oxidative stress analyses. Urine was also collected for clinical effects related to hemolysis. Under the study conditions, our results showed that the blood parameters such as RBCs, hemoglobin concentration, and white blood cells tended to increase in response to PGME and PGBE exposures. These results raise questions about the possible effects in people regularly exposed to higher concentrations, such as workers.

Toxicity of Propylene Glycol Extract of Propolis on Central Nervous System and Liver in Pregnant and Neonatal Rats.

BACKGROUND: Propolis has become one of the most preferred supplements due to its beneficial biological properties. Organic (water and vegetable oils) and chemical (ethyl alcohol, propylene glycol, and glycerol) solvents are used for propolis extraction. However, the effects of these chemicals on health should be taken into account. OBJECTIVES: In this study, the effects of propolis extracts on health were evaluated. METHODS: 32 pregnant Wistar albino rats and 64 neonatal/young adults were given three different extractions of propolis (propylene glycol, water, and olive oil). Histopathological analyses were performed on the liver and brain, and blood samples were taken from the hearts of rats. RESULTS: Histopathological scoring showed that the intensity of pycnotic hepatocyte, sinusoidal dilatation, and bleeding was high in liver samples of pregnant and baby rats given propylene glycol extract of propolis (p<0.05). Propylene glycol extract caused dilatation of blood vessels and apoptosis of neurons in brain tissue. The histopathological score was significantly lower in liver and brain tissues of rats treated with water and olive oil extract compared to propylene propolis groups (p<0.05). Liver enzyme levels in the blood increased in propylene propolis rats (p<0.05). CONCLUSION: Histopathological changes and biochemical alterations may indicate that propylene glycol extracts of propolis are more toxic than olive oil and water extracts. Therefore, olive oil and water extracts of propolis are more reliable than propylene glycol extract in pregnant and infant rats.

Propylene glycol, skin sensitisation and allergic contact dermatitis: A scientific and regulatory conundrum.

Propylene glycol (PG) has widespread use in pharmaceuticals, cosmetics, fragrances and personal care products. PG is not classified as hazardous under the Globally Harmonised System of Classification and Labelling of Chemicals (GHS) but poses an intriguing scientific and regulatory conundrum with respect to allergic contact dermatitis (ACD), the uncertainty being whether and to what extent PG has the potential to induce skin sensitisation. In this article we review the results of predictive tests for skin sensitisation with PG, and clinical evidence for ACD. Patch testing in humans points to PG having the potential to be a weak allergen under certain conditions, and an uncommon cause of ACD in subjects without underlying/pre-disposing skin conditions. In clear contrast PG is negative in predictive toxicology tests for skin sensitisation, including guinea pig and mouse models (e.g. local lymph node assay), validated in vitro test methods that measure various key events in the pathway leading to skin sensitisation, and predictive methods in humans (Human Repeat Insult Patch and Human Maximisation Tests). We here explore the possible scientific basis for this intriguing inconsistency, recognising there are arguably no known contact allergens that are universally negative in, in vitro, animal and human predictive tests methods.

Carbonyl Profiles of Electronic Nicotine Delivery System (ENDS) Aerosols Reflect Both the Chemical Composition and the Numbers of E-Liquid Ingredients-Focus on the In Vitro Toxicity of Strawberry and Vanilla Flavors.

Propylene glycol (PG) and glycerin (G) are the most widely used humectants in electronic nicotine delivery system (ENDS) devices. Carbonyls are present in aerosols produced when ENDS devices heat PG and G. Whether aerosolized PG and G are innocuous to the lungs has not been established. Here, we determined the chemical profiles of ENDS aerosols containing three humectant ratios (30/70, 50/50 and 70/30, PG/VG), for three flavors (strawberry, vanilla and Catalan cream) containing either 12 or 18 mg/mL of nicotine. Additionally, we examined the in vitro toxicity of the strawberry- and vanilla-flavored ENDS aerosol in human lung epithelial cells (BEAS-2B) exposed at the air-liquid interface for 1 h. For strawberry- and vanilla-flavored aerosols produced by a 3rd-generation ENDS device with the same PG/G ratio, the e-liquid nicotine content of 12 and 18 mg/mL did not transfer to the aerosol with substantial differences in concentrations. Our data also indicate the presence of carbonyls in all three flavored e-cig aerosols analyzed, with levels exceeding 1 µg/puff for acetone, butyraldehyde, and acetaldehyde, in strawberry-, vanilla, and Catalan cream-flavored e-cig aerosols, respectively. Furthermore, closed-system ENDS of the fourth generation emitted trace levels of carbonyls in the aerosols (<0.3 µg/puff), while open-system tank-style ENDS of the third generation produced elevated levels of harmful chemicals, including acrolein (>1 µg/puff), formaldehyde (>5 µg/puff), and m- & p-tolualdehyde (>4 µg/puff). Moreover, under non-cytotoxic conditions, BEAS-2B cells exposed to strawberry-flavored aerosols exhibited significantly increased reactive oxygen and nitric oxide species (ROS/NOS) levels in cell media compared to air controls, while vanilla-flavored ENDS aerosols up-regulated the expression of pro-inflammatory and oxidative stress markers. Our data suggest (a) that ENDS aerosol chemical composition will vary based upon the presence and concentration of the initial e-liquid ingredients, with a pronounced impact of the flavoring components; and (b) short-term exposures to flavored ENDS aerosols may impair lung cells' redox signaling in a flavor-specific manner.

E-cigarette vapor exposure in utero causes long-term pulmonary effects in offspring.

The in utero environment is sensitive to toxicant exposure, altering the health and growth of the fetus, and thus sensitive to contaminant exposure. Though recent clinical data suggest that e-cigarette use does no further harm to birth outcomes than a nicotine patch, this does not account for the effects of vaping during pregnancy on the long-term health of offspring. Pregnant mice were exposed to: 1) e-cigarette vapor with nicotine (PV + Nic; 2% Nic in 50:50 propylene glycol: vegetable glycerin), 2) e-cigarette vapor without nicotine [PV; (50:50 propylene glycol:vegetable glycerin)], or 3) HEPA filtered air (FA). Dams were removed from exposure upon giving birth. At 5 mo of age, pulmonary function tests on the offspring revealed female and male mice from the PV group had greater lung stiffness (Ers) and alveolar stiffness (H) compared with the FA group. Furthermore, baseline compliance (Crs) was reduced in female mice from the PV group and in male mice from the PV and PV + Nic groups. Lastly, female mice had decreased forced expiratory volume (FEV0.1) in the PV group, but not in the male groups, compared with the FA group. Lung histology revealed increased collagen deposition around the vessels/airways and in alveolar tissue in PV and PV + Nic groups. Furthermore, goblet hyperplasia was observed in PV male and PV/PV + Nic female mice. Our work shows that in utero exposure to e-cigarette vapor, regardless of nicotine presence, causes lung dysfunction and structural impairments that persist in the offspring to adulthood.

Electronic cigarette vaping with aged coils causes acute lung injury in mice.

Electronic cigarettes (e-cigarettes) have been used widely as an alternative to conventional cigarettes and have become particularly popular among young adults. A growing body of evidence has shown that e-cigarettes are associated with acute lung injury and adverse effects in multiple other organs. Previous studies showed that high emissions of aldehydes (formaldehyde and acetaldehyde) in aerosols were associated with increased usage of the same e-cigarette coils. However, the impact on lung function of using aged coils has not been reported. We investigated the relationship between coil age and acute lung injury in mice exposed to experimental vaping for 1 h (2 puffs/min, 100 ml/puff). The e-liquid contains propylene glycol and vegetable glycerin (50:50, vol) only. The concentrations of formaldehyde and acetaldehyde in the vaping aerosols increased with age of the nichrome coils starting at 1200 puffs. Mice exposed to e-cigarette aerosols produced from 1800, but not 0 or 900, puff-aged coils caused acute lung injury, increased lung wet/dry weight ratio, and induced lung inflammation (IL-6, TNF-α, IL-1ß, MIP-2). Exposure to vaping aerosols from 1800 puff-aged coils decreased heart rate, respiratory rate, and oxygen saturation in mice compared to mice exposed to air or aerosols from new coils. In conclusion, we observed that the concentration of aldehydes (formaldehyde and acetaldehyde) increased with repeated and prolonged usage of e-cigarette coils. Exposure to high levels of aldehyde in vaping aerosol was associated with acute lung injury in mice. These findings show significant risk of lung injury associated with prolonged use of e-cigarette devices.

Multiple cryoprotectant toxicity model for vitrification solution optimization.

Vitrification is a promising cryopreservation technique for complex specimens such as tissues and organs. However, it is challenging to identify mixtures of cryoprotectants (CPAs) that prevent ice formation without exerting excessive toxicity. In this work, we developed a multi-CPA toxicity model that predicts the toxicity kinetics of mixtures containing five of the most common CPAs used in the field (glycerol, dimethyl sulfoxide (DMSO), propylene glycol, ethylene glycol, and formamide). The model accounts for specific toxicity, non-specific toxicity, and interactions between CPAs. The proposed model shows reasonable agreement with training data for single and binary CPA solutions, as well as ternary CPA solution validation data. Sloppy model analysis was used to examine the model parameters that were most important for predictions, providing clues about mechanisms of toxicity. This analysis revealed that the model terms for non-specific toxicity were particularly important, especially the non-specific toxicity of propylene glycol, as well as model terms for specific toxicity of formamide and interactions between formamide and glycerol. To demonstrate the potential for model-based design of vitrification methods, we paired the multi-CPA toxicity model with a published vitrification/devitrification model to identify vitrifiable CPA mixtures that are predicted to have minimal toxicity. The resulting optimized vitrification solution composition was a mixture of 7.4 molal glycerol, 1.4 molal DMSO, and 2.4 molal formamide. This demonstrates the potential for mathematical optimization of vitrification solution composition and sets the stage for future studies to optimize the complete vitrification process, including CPA mixture composition and CPA addition and removal methods.

Propylene glycol, a component of electronic cigarette liquid, damages epithelial cells in human small airways.

BACKGROUND: Electronic cigarettes (e-cigarettes) are used worldwide as a substitute for conventional cigarettes. Although they are primarily intended to support smoking cessation, e-cigarettes have been identified as a gateway to smoking habits for young people. Multiple recent reports have described the health effects of inhaling e-cigarettes. E-cigarette liquid (e-liquid) is mainly composed of propylene glycol (PG) and glycerol (Gly), and the aerosol generated by these devices primarily contains these two components. Thus, this study aimed to evaluate the effects of PG and Gly on human small airway epithelial cells (SAECs). METHODS: SAECs were exposed to PG or Gly, and cell proliferation, cell viability, lactate dehydrogenase (LDH) release, DNA damage, cell cycle, and apoptosis were evaluated. Additionally, SAECs derived from chronic obstructive pulmonary disease (COPD) patients (COPD-SAECs) were investigated. RESULTS: Exposure of SAECs to PG significantly inhibited proliferation (1%, PG, p = 0.021; 2-4% PG, p < 0.0001) and decreased cell viability (1-4% PG, p < 0.0001) in a concentration-dependent manner. Gly elicited similar effects but to a reduced degree as compared to the same concentration of PG. PG also increased LDH release in a concentration-dependent manner (3% PG, p = 0.0055; 4% PG, p < 0.0001), whereas Gly did not show a significant effect on LDH release. SAECs exposed to 4% PG contained more cells that were positive for phosphorylated histone H2AX (p < 0.0001), a marker of DNA damage, and an increased proportion of cells in the G1 phase (p < 0.0001) and increased p21 expression (p = 0.0005). Moreover, caspase 3/7-activated cells and cleaved poly (ADP-ribose) polymerase 1 expression were increased in SAECs exposed to 4% PG (p = 0.0054). Furthermore, comparing COPD-SAECs to SAECs without COPD in PG exposure, cell proliferation, cell viability, DNA damage and apoptosis were significantly greater in COPD-SAECs. CONCLUSION: PG damaged SAECs more than Gly. In addition, COPD-SAECs were more susceptible to PG than SAECs without COPD. Usage of e-cigarettes may be harmful to the respiratory system, especially in patients with COPD.

Assessment of inhalation toxicity of cigarette smoke and aerosols from flavor mixtures: 5-week study in A/J mice.

Most flavors used in e-liquids are generally recognized as safe for oral consumption, but their potential effects when inhaled are not well characterized. In vivo inhalation studies of flavor ingredients in e-liquids are scarce. A structure-based grouping approach was used to select 38 flavor group representatives (FGR) on the basis of known and in silico-predicted toxicological data. These FGRs were combined to create prototype e-liquid formulations and tested against cigarette smoke (CS) in a 5-week inhalation study. Female A/J mice were whole-body exposed for 6 h/day, 5 days/week, for 5 weeks to air, mainstream CS, or aerosols from (1) test formulations containing propylene glycol (PG), vegetable glycerol (VG), nicotine (N; 2% w/w), and flavor (F) mixtures at low (4.6% w/w), medium (9.3% w/w), or high (18.6% w/w) concentration or (2) base formulation (PG/VG/N). Male A/J mice were exposed to air, PG/VG/N, or PG/VG/N/F-high under the same exposure regimen. There were no significant mortality or in-life clinical findings in the treatment groups, with only transient weight loss during the early exposure adaptation period. While exposure to flavor aerosols did not cause notable lung inflammation, it caused only minimal adaptive changes in the larynx and nasal epithelia. In contrast, exposure to CS resulted in lung inflammation and moderate-to-severe changes in the epithelia of the nose, larynx, and trachea. In summary, the study evaluates an approach for assessing the inhalation toxicity potential of flavor mixtures, thereby informing the selection of flavor exposure concentrations (up to 18.6%) for a future chronic inhalation study.

Revisions to Limits for Propylene Glycol in Spacecraft Air.

INTRODUCTION: The previous Spacecraft Maximal Allowable Concentrations (SMACs) for propylene glycol were established based on a study of rodents exposed to propylene glycol (PG) aerosol for 6 h/d, 5 d/wk for 90 d. This study has been used as the basis for the few existing limits, but all exposure concentrations were well above the saturated vapor concentration of ∼100 ppm for pure propylene glycol at room temperature. For this reason, the Environmental Protection Agency and the Agency for Toxic Substances and Disease Registry noted that the method used to generate the aerosols for the two published studies of animal exposures are not relevant to exposure conditions for the general public, and most regulatory agencies have not established inhalation limits for propylene glycol, citing lack of data. Since publication of the PG SMACs in 2008, an acute inhalation study was conducted in healthy human subjects which allows us to revise our assessment. This manuscript provides the rationale for increasing the prior limits for PG in spacecraft air from 32 and 17 ppm to 64 and 32 ppm for off-nominal scenarios/releases (1-h and 24-h limits) and from 9, 3, and 1.5 ppm to 32 ppm for all nominal timeframes (7, 30, and 180 d). Due to a lack of longer-term exposure data, NASA has elected to eliminate the 1000-d SMAC limit at this time.Ryder VE, Williams ES. Revisions to limits for propylene glycol in spacecraft air. Aerosp Med Hum Perform. 2022; 93(5):467-469.

Blood absorption toxicokinetics of glycol ethers after inhalation: A human controlled study.

Glycol ethers are organic solvents present in countless products for professional and domestic use. The main toxicological concerns are hematotoxicity, respiratory and reproductive toxicity. The general population can be exposed when using products containing one or several glycol ethers that evaporate or if sprayed, generate aerosols that can be inhaled. The rate at which glycol ethers enters blood following inhalation exposure are unknown in humans, and chemical risk assessors only rely on animal and in vitro toxicity studies. Propylene glycol monomethyl ether (PGME) and propylene glycol monobutyl ether (PGBE) are two examples of glycol ethers used worldwide. Our study aimed to provide human toxicokinetic data after inhalation exposure of low PGME and PGBE concentrations tested alone or in mixture. Healthy participants (n = 28) were exposed to 35 ppm (131 mg/m3) of PGME and 15 ppm (i.e., 83 mg/m3) of PGBE for 2 or 6 h. Blood was regularly collected during the exposure sessions. PGME and PGBE were immediately bioavailable in blood during exposure, and the mean absorption rates were up to 13 µg/L/min and 2.45 µg/L/min, respectively. Maximum mean blood concentration (Cmax) was 2.91 mg/L and 0.41 mg/L for PGME and PGBE. The cumulative internal doses over time (area under the curve, AUC) were 11 mg∗h/L and 1.81 mg∗h/L for PGME and PGBE. PGME and PGBE total blood uptake could possibly be higher in physically active individuals, such as workers. We recommend that glycol ethers present on the market undergo toxicological testing with the internal doses we found in our toxicokinetic study.

Propylene glycol toxicity from compulsive corn starch ingestion.

INTRODUCTION: Propylene glycol (PG) is usually considered safe, however, toxicity can develop with high doses or when used for prolonged periods of time. PG can be found in some medications as well as some food products. We report a case of likely PG toxicity that occurred after compulsive daily ingestion of large amounts of corn starch. CASE REPORT: Our patient initially presented to an outside hospital (OSH) via ambulance for altered mental status. Her mental status improved after her blood sugar of 25 was corrected. On admission to OSH Emergency Department her initial vital signs included a heart rate of 115 bpm, blood pressure 113/59 mm/hg, temperature 35.8C. Pertinent labs included: sodium 119 mEq/L, bicarbonate 9 mEq/L, anion gap 29 mEq/L, creatinine 2.5 mg/dL and lactic acid 20 mEq/L. On transfer to our hospital her repeat lactic acid was 20 mEq/L, osmolar gap was 20. Her PG level, which was drawn several hours after her initial presentation, was 11 mg/dL. Our patient noted that she ingested a 16 oz. package of corn starch mixed with baking soda approximately every 2 days. Given the concerns for PG she was underwent intermittent hemodialysis. PG and lactic acid levels improved, however, she ultimately died due to complications from her hospitalization. DISCUSSION: PG causes toxicity through metabolism to lactic acid. While there are small amounts in food products and medications, under the right circumstances, PG can accumulate and lead to significant toxicity.

Quantification and cytotoxicity of degradation products (chloropropanols) in sucralose containing e-liquids with propylene glycol and glycerol as base.

Electronic cigarettes (e-cigarettes) have gained increasing popularity in recent years, mostly because they are supposed to be less harmful than regular cigarettes. Therefore, it is highly imperative to investigate possible noxious effects to protect the consumers. E-liquids consist of propylene glycol, glycerol, aroma compounds and sweeteners. One of these sweeteners is a chlorinated version of sucrose, namely sucralose. The aim of this work was to investigate degradation products of sucralose in the presence of propylene glycol and glycerol at different temperatures of commercially available e-cigarettes. Chemical analysis and biological tests were simultaneously performed on e-liquid aerosol condensates. The results of the chemical analysis, which was executed by employing GC-MS/GC-FID, demonstrated high amounts of various chloropropanols. The most abundant one is extremely toxic, namely 3-chloropropane-1,2-diol, which can be detected at concentrations ranging up to 10,000 mg/kg. Furthermore, a cytotoxicity investigation of the condensates was performed on HUVEC/Tert2 cells in which metabolic activity was determined by means of resazurin assay. The cellular metabolic activity significantly decreased by treatment with e-liquid aerosol condensate. Due to the results of this study, we advise against the use of sucralose as sweetener in e-liquids.

Acute and subacute oral toxicity of propylene glycol enantiomers in mice and the underlying nephrotoxic mechanism.

Propylene glycol (PG; 1,2-propanediol) has been commonly used as a food additive and vehicle in pharmaceutical preparations. PG can form rectus (R-) enantiomers and sinister (S-) enantiomers. Herein, Kunming mice were used as the animal model to evaluate the acute and subacute oral toxicity of R-PG, S-PG and RS-PG (1:1 racemic mixture of R-PG and S-PG). The median lethal doses of R-PG, S-PG and RS-PG administered by oral gavage to mice were 22.81 g/kg, 26.62 g/kg and 24.92 g/kg, respectively. In the 28-day oral subacute toxicity study, the body weight, organ weights, serum biochemical, and renal histology were examined. There was no difference in subacute toxicity among R-PG, S-PG and RS-PG. The administration of 1 and 5 g/kg/day PG for 28 days caused nephrotoxicity. The kidney somatic index and levels of blood urea nitrogen exhibited a significant increase. Moreover, the activities of superoxide dismutase, catalase, and glutathione peroxidase significantly decreased after the treatment with PG. The levels of malondialdehyde, tumor necrosis factor α, interleukin 1ß, and interleukin 6 significantly increased in the kidney. The results show that the nephrotoxic effects of PG are induced by oxidative stress, and the activation of the inflammatory response is mediated by the NF-κB signaling pathway. Together, these findings provide information on R-PG, S-PG and RS-PG treatments for the risk assessment of toxicity and effects on human health.

The in vitro ToxTracker and Aneugen Clastogen Evaluation extension assay as a tool in the assessment of relative genotoxic potential of e-liquids and their aerosols.

In vitro (geno)toxicity assessment of electronic vapour products (EVPs), relative to conventional cigarette, currently uses assays, including the micronucleus and Ames tests. Whilst informative on induction of a finite endpoint and relative risk posed by test articles, such assays could benefit from mechanistic supplementation. The ToxTracker and Aneugen Clastogen Evaluation analysis can indicate the activation of reporters associated with (geno)toxicity, including DNA damage, oxidative stress, the p53-related stress response and protein damage. Here, we tested for the different effects of a selection of neat e-liquids, EVP aerosols and Kentucky reference 1R6F cigarette smoke samples in the ToxTracker assay. The assay was initially validated to assess whether a mixture of e-liquid base components, propylene glycol (PG) and vegetable glycerine (VG) had interfering effects within the system. This was achieved by spiking three positive controls into the system with neat PG/VG or phosphate-buffered saline bubbled (bPBS) PG/VG aerosol (nicotine and flavour free). PG/VG did not greatly affect responses induced by the compounds. Next, when compared to cigarette smoke samples, neat e-liquids and bPBS aerosols (tobacco flavour; 1.6% freebase nicotine, 1.6% nicotine salt or 0% nicotine) exhibited reduced and less complex responses. Tested up to a 10% concentration, EVP aerosol bPBS did not induce any ToxTracker reporters. Neat e-liquids, tested up to 1%, induced oxidative stress reporters, thought to be due to their effects on osmolarity in vitro. E-liquid nicotine content did not affect responses induced. Additionally, spiking nicotine alone only induced an oxidative stress response at a supraphysiological level. In conclusion, the ToxTracker assay is a quick, informative screen for genotoxic potential and mechanisms of a variety of (compositionally complex) samples, derived from cigarettes and EVPs. This assay has the potential for future application in the assessment battery for next-generation (smoking alternative) products, including EVPs.